Evaluation of Pyrophosphate-Driven Proton Pumps in Saccharomyces cerevisiae under Stress Conditions.

In Saccharomyces cerevisiae, pH homeostasis is reliant on ATP due to the use of proton-translocating ATPase (H+-ATPase) which constitutes a major drain within cellular ATP supply. Here, an exogenous proton-translocating pyrophosphatase (H+-PPase) from Arabidopsis thaliana, which uses inorganic pyrophosphate (PPi) rather than ATP, was evaluated for its effect on reducing the ATP burden. The H+-Ppase was localized to the vacuolar membrane or to the cell membrane, and their impact was studied under acetate stress at a low pH. Biosensors (pHluorin and mQueen-2m) were used to observe changes in intracellular pH (pHi) and ATP levels during growth on either glucose or xylose. A significant improvement of 35% in the growth rate at a pH of 3.7 and 6 g·L-1 acetic acid stress was observed in the vacuolar membrane H+-PPase strain compared to the parent strain. ATP levels were elevated in the same strain during anaerobic glucose and xylose fermentations. During anaerobic xylose fermentations, co-expression of pHluorin and a vacuolar membrane H+-PPase improved the growth characteristics by means of an improved growth rate (11.4%) and elongated logarithmic growth duration. Our study identified a potential method for improving productivity in the use of S. cerevisiae as a cell factory under the harsh conditions present in industry.

Non-inhibitory levels of oxygen during cultivation increase freeze-drying stress tolerance in Limosilactobacillus reuteri DSM 17938.

The physiological effects of oxygen on Limosilactobacillus reuteri DSM 17938 during cultivation and the ensuing properties of the freeze-dried probiotic product was investigated. On-line flow cytometry and k-means clustering gating was used to follow growth and viability in real time during cultivation. The bacterium tolerated aeration at 500 mL/min, with a growth rate of 0.74 ± 0.13 h-1 which demonstrated that low levels of oxygen did not influence the growth kinetics of the bacterium. Modulation of the redox metabolism was, however, seen already at non-inhibitory oxygen levels by 1.5-fold higher production of acetate and 1.5-fold lower ethanol production. A significantly higher survival rate in the freeze-dried product was observed for cells cultivated in presence of oxygen compared to absence of oxygen (61.8% ± 2.4% vs. 11.5% ± 4.3%), coinciding with a higher degree of unsaturated fatty acids (UFA:SFA ratio of 10 for air sparged vs. 3.59 for N2 sparged conditions.). Oxygen also resulted in improved bile tolerance and boosted 5'nucleotidase activity (370 U/L vs. 240 U/L in N2 sparged conditions) but lower tolerance to acidic conditions compared bacteria grown under complete anaerobic conditions which survived up to 90 min of exposure at pH 2. Overall, our results indicate the controlled supply of oxygen during production may be used as means for probiotic activity optimization of L. reuteri DSM 17938.

Immobilization techniques improve volumetric hydrogen productivity of Caldicellulosiruptor species in a modified continuous stirred tank reactor.

BACKGROUND: Co-cultures and cell immobilization have been used for retaining biomass in a bioreactor, with the aim to improve the volumetric hydrogen productivity (QH2). Caldicellulosiruptor kronotskyensis is a strong cellulolytic species that possesses tapirin proteins for attaching on lignocellulosic materials. C. owensensis has its reputation as a biofilm former. It was investigated whether continuous co-cultures of these two species with different types of carriers can improve the QH2. RESULTS: QH2 up to 30 ± 0.2 mmol L-1 h-1 was obtained during pure culture of C. kronotskyensis with combined acrylic fibres and chitosan. In addition, the yield of hydrogen was 2.95 ± 0.1 mol H2 mol-1 sugars at a dilution rate (D) of 0.3 h-1. However, the second-best QH2 26.4 ± 1.9 mmol L-1 h-1 and 25.4 ± 0.6 mmol L-1 h-1 were obtained with a co-culture of C. kronotskyensis and C. owensensis with acrylic fibres only and a pure culture of C. kronotskyensis with acrylic fibres, respectively. Interestingly, the population dynamics revealed that C. kronotskyensis was the dominant species in the biofilm fraction, whereas C. owensensis was the dominant species in the planktonic phase. The highest amount of c-di-GMP (260 ± 27.3 µM at a D of 0.2 h-1) were found with the co-culture of C. kronotskyensis and C. owensensis without a carrier. This could be due to Caldicellulosiruptor producing c-di-GMP as a second messenger for regulation of the biofilms under the high dilution rate (D) to prevent washout. CONCLUSIONS: The cell immobilization strategy using a combination of carriers exhibited a promising approach to enhance the QH2. The QH2 obtained during the continuous culture of C. kronotskyensis with combined acrylic fibres and chitosan gave the highest QH2 among the pure culture and mixed cultures of Caldicellulosiruptor in the current study. Moreover, it was the highest QH2 among all cultures of Caldicellulosiruptor species studied so far.

Cross-Feeding and Enzymatic Catabolism for Mannan-Oligosaccharide Utilization by the Butyrate-Producing Gut Bacterium Roseburia hominis A2-183.

ß-Mannan is abundant in the human diet and in hemicellulose derived from softwood. Linear or galactose-substituted ß-mannan-oligosaccharides (MOS/GMOSs) derived from ß-mannan are considered emerging prebiotics that could stimulate health-associated gut microbiota. However, the underlying mechanisms are not yet resolved. Therefore, this study investigated the cross-feeding and metabolic interactions between Bifidobacterium adolescentis ATCC 15703, an acetate producer, and Roseburia hominis A2-183 DSMZ 16839, a butyrate producer, during utilization of MOS/GMOSs. Cocultivation studies suggest that both strains coexist due to differential MOS/GMOS utilization, along with the cross-feeding of acetate from B. adolescentis E194a to R. hominis A2-183. The data suggest that R. hominis A2-183 efficiently utilizes MOS/GMOS in mono- and cocultivation. Notably, we observed the transcriptional upregulation of certain genes within a dedicated MOS/GMOS utilization locus (RhMosUL), and an exo-oligomannosidase (RhMan113A) gene located distally in the R. hominis A2-183 genome. Significantly, biochemical analysis of ß-1,4 mannan-oligosaccharide phosphorylase (RhMOP130A), α-galactosidase (RhGal36A), and exo-oligomannosidase (RhMan113A) suggested their potential synergistic role in the initial utilization of MOS/GMOSs. Thus, our results enhance the understanding of MOS/GMOS utilization by potential health-promoting human gut microbiota and highlight the role of cross-feeding and metabolic interactions between two secondary mannan degraders inhabiting the same ecological niche in the gut.

Characterization and adaptation of Caldicellulosiruptor strains to higher sugar concentrations, targeting enhanced hydrogen production from lignocellulosic hydrolysates.

BACKGROUND: The members of the genus Caldicellulosiruptor have the potential for future integration into a biorefinery system due to their capacity to generate hydrogen close to the theoretical limit of 4 mol H2/mol hexose, use a wide range of sugars and can grow on numerous lignocellulose hydrolysates. However, members of this genus are unable to survive in high sugar concentrations, limiting their ability to grow on more concentrated hydrolysates, thus impeding their industrial applicability. In this study five members of this genus, C. owensensis, C. kronotskyensis, C. bescii, C. acetigenus and C. kristjanssonii, were developed to tolerate higher sugar concentrations through an adaptive laboratory evolution (ALE) process. The developed mixed population C. owensensis CO80 was further studied and accompanied by the development of a kinetic model based on Monod kinetics to quantitatively compare it with the parental strain. RESULTS: Mixed populations of Caldicellulosiruptor tolerant to higher glucose concentrations were obtained with C. owensensis adapted to grow up to 80 g/L glucose; other strains in particular C. kristjanssonii demonstrated a greater restriction to adaptation. The C. owensensis CO80 mixed population was further studied and demonstrated the ability to grow in glucose concentrations up to 80 g/L glucose, but with reduced volumetric hydrogen productivities ([Formula: see text]) and incomplete sugar conversion at elevated glucose concentrations. In addition, the carbon yield decreased with elevated concentrations of glucose. The ability of the mixed population C. owensensis CO80 to grow in high glucose concentrations was further described with a kinetic growth model, which revealed that the critical sugar concentration of the cells increased fourfold when cultivated at higher concentrations. When co-cultured with the adapted C. saccharolyticus G5 mixed culture at a hydraulic retention time (HRT) of 20 h, C. owensensis constituted only 0.09-1.58% of the population in suspension. CONCLUSIONS: The adaptation of members of the Caldicellulosiruptor genus to higher sugar concentrations established that the ability to develop improved strains via ALE is species dependent, with C. owensensis adapted to grow on 80 g/L, whereas C. kristjanssonii could only be adapted to 30 g/L glucose. Although C. owensensis CO80 was adapted to a higher sugar concentration, this mixed population demonstrated reduced [Formula: see text] with elevated glucose concentrations. This would indicate that while ALE permits adaptation to elevated sugar concentrations, this approach does not result in improved fermentation performances at these higher sugar concentrations. Moreover, the observation that planktonic mixed culture of CO80 was outcompeted by an adapted C. saccharolyticus, when co-cultivated in continuous mode, indicates that the robustness of CO80 mixed culture should be improved for industrial application.

Enhanced Protocatechuic Acid Production From Glucose Using Pseudomonas putida 3-Dehydroshikimate Dehydratase Expressed in a Phenylalanine-Overproducing Mutant of Escherichia coli.

Protocatechuic acid (PCA) is a strong antioxidant and is also a potential platform for polymer building blocks like vanillic acid, vanillin, muconic acid, and adipic acid. This report presents a study on PCA production from glucose via the shikimate pathway precursor 3-dehydroshikimate by heterologous expression of a gene encoding 3-dehydroshikimate dehydratase in Escherichia coli. The phenylalanine overproducing E. coli strain, engineered to relieve the allosteric inhibition of 3-deoxy-7-phosphoheptulonate synthase by the aromatic amino acids, was shown to give a higher yield of PCA than the unmodified strain under aerobic conditions. Highest PCA yield of 18 mol% per mol glucose and concentration of 4.2 g/L was obtained at a productivity of 0.079 g/L/h during cultivation in fed-batch mode using a feed of glucose and ammonium salt. Acetate was formed as a major side-product indicating a shift to catabolic metabolism as a result of feedback inhibition of the enzymes including 3-dehydroshikimate dehydratase by PCA when reaching a critical concentration. Indirect measurement of proton motive force by flow cytometry revealed no membrane damage of the cells by PCA, which was thus ruled out as a cause for affecting PCA formation.

Characterization of simultaneous uptake of xylose and glucose in Caldicellulosiruptor kronotskyensis for optimal hydrogen production.

BACKGROUND: Caldicellulosiruptor kronotskyensis has gained interest for its ability to grow on various lignocellulosic biomass. The aim of this study was to investigate the growth profiles of C. kronotskyensis in the presence of mixtures of glucose-xylose. Recently, we characterized a diauxic-like pattern for C. saccharolyticus on lignocellulosic sugar mixtures. In this study, we aimed to investigate further whether C. kronotskyensis has adapted to uptake glucose in the disaccharide form (cellobiose) rather than the monosaccharide (glucose). RESULTS: Interestingly, growth of C. kronotskyensis on glucose and xylose mixtures did not display diauxic-like growth patterns. Closer investigation revealed that, in contrast to C. saccharolyticus, C. kronotskyensis does not possess a second uptake system for glucose. Both C. saccharolyticus and C. kronotskyensis share the characteristics of preferring xylose over glucose. Growth on xylose was twice as fast (µmax = 0.57 h-1) as on glucose (µmax = 0.28 h-1). A study of the sugar uptake was made with different glucose-xylose ratios to find a kinetic relationship between the two sugars for transport into the cell. High concentrations of glucose inhibited xylose uptake and vice versa. The inhibition constants were estimated to be KI,glu = 0.01 cmol L-1 and KI,xyl = 0.001 cmol L-1, hence glucose uptake was more severely inhibited by xylose uptake. Bioinformatics analysis could not exclude that C. kronotskyensis possesses more than one transporter for glucose. As a next step it was investigated whether glucose uptake by C. kronotskyensis improved in the form of cellobiose. Indeed, cellobiose is taken up faster than glucose; nevertheless, the growth rate on each sugar remained similar. CONCLUSIONS: C. kronotskyensis possesses a xylose transporter that might take up glucose at an inferior rate even in the absence of xylose. Alternatively, glucose can be taken up in the form of cellobiose, but growth performance is still inferior to growth on xylose. Therefore, we propose that the catabolism of C. kronotskyensis has adapted more strongly to pentose rather than hexose, thereby having obtained a specific survival edge in thermophilic lignocellulosic degradation communities.

Engineering the carotenoid biosynthetic pathway in Rhodothermus marinus for lycopene production.

Rhodothermus marinus has the potential to be well suited for biorefineries, as an aerobic thermophile that produces thermostable enzymes and is able to utilize polysaccharides from different 2nd and 3rd generation biomass. The bacterium produces valuable chemicals such as carotenoids. However, the native carotenoids are not established for industrial production and R. marinus needs to be genetically modified to produce higher value carotenoids. Here we genetically modified the carotenoid biosynthetic gene cluster resulting in three different mutants, most importantly the lycopene producing mutant TK-3 (ΔtrpBΔpurAΔcruFcrtB::trpBcrtB T.thermophilus ). The genetic modifications and subsequent structural analysis of carotenoids helped clarify the carotenoid biosynthetic pathway in R. marinus. The nucleotide sequences encoding the enzymes phytoene synthase (CrtB) and the previously unidentified 1',2'-hydratase (CruF) were found fused together and encoded by a single gene in R. marinus. Deleting only the cruF part of the gene did not result in an active CrtB enzyme. However, by deleting the entire gene and inserting the crtB gene from Thermus thermophilus, a mutant strain was obtained, producing lycopene as the sole carotenoid. The lycopene produced by TK-3 was quantified as 0.49 â€‹g/kg CDW (cell dry weight).

Cultivation technology development of Rhodothermus marinus DSM 16675.

This work presents an evaluation of batch, fed-batch, and sequential batch cultivation techniques for production of R. marinus DSM 16675 and its exopolysaccharides (EPSs) and carotenoids in a bioreactor, using lysogeny broth (LB) and marine broth (MB), respectively, in both cases supplemented with 10 g/L maltose. Batch cultivation using LB supplemented with maltose (LBmalt) resulted in higher cell density (OD620 = 6.6) than use of MBmalt (OD620 = 1.7). Sequential batch cultivation increased the cell density threefold (OD620 = 20) in LBmalt and eightfold (OD620 = 14) in MBmalt. In both single and sequential batches, the production of carotenoids and EPSs using LBmalt was detected in the exponential phase and stationary phase, respectively, while in MBmalt formation of both products was detectable in both the exponential and stationary phases of the culture. Heteropolymeric EPSs were produced with an overall volumetric productivity (QE) of 0.67 (mg/L h) in MBmalt and the polymer contained xylose. In LB, QE was lower (0.1 mg/L h) and xylose could not be detected in the composition of the produced EPSs. In conclusion, this study showed the importance of a process design and medium source for production of R. marinus DSM 16675 and its metabolites.

Impact of the fermentation parameters pH and temperature on stress resilience of Lactobacillus reuteri DSM 17938.

This study was undertaken to investigate the impact of culture pH (4.5-6.5) and temperature (32-37 °C) on the stress resilience of Lactobacillus reuteri DSM 17938 during freeze-drying and post freeze-drying exposure to low pH (pH 2) and bile salts. Response-surface methodology analysis revealed that freeze-drying survival rates [Formula: see text] were linearly related to pH with the highest survival rate of 80% when cells were cultured at pH 6.5 and the lowest was 40% when cells were cultured at pH 4.5. The analysis further revealed that within the chosen temperature range the culture temperature did not significantly affect the freeze-drying survival rate. However, fermentation at pH 4.5 led to better survival rates when rehydrated cells were exposed to low pH shock or bile salts. Thus, the effect of pH on freeze-drying survival was in contrast to effects on low pH and bile salts stress tolerance. The rationale behind this irreconcilability is based on the responses being dissimilar and are not tuned to each other. Culturing strain DSM 17938 at pH values higher than 5.5 could be a useful option to improve the survivability and increase viable cell numbers in the final freeze-dried product. However, the dissimilar responses for the process- and application parameters tested here suggest that an optimal compromise has to be found in order to obtain the most functional probiotic product possible.

Hydrogen and polyhydroxybutyrate production from wheat straw hydrolysate using Caldicellulosiruptor species and Ralstonia eutropha in a coupled process.

This report presents an integrated biorefinery concept in which wheat straw hydrolysate was treated with co-cultures of osmotolerant thermophilic bacterial strains, Caldicellulosiruptor saccharolyticus and C. owensensis to obtain hydrogen, while the liquid effluent containing acetate and residual glucose was used as feed for polyhydroxybutyrate (PHB) production by Ralstonia eutropha. The Caldicellulosiruptor spp. co-culture consumed 10.8 g/L of pretreated straw sugars, glucose and xylose, producing 134 mmol H2/L. PHB accumulation by R. eutropha was first studied in minimal salts medium using acetate with/without glucose as carbon source. Addition of salts promoted cell growth and PHB production in the effluent. Fed-batch cultivation in a nitrogen limited medium with 40% (v/v) aeration resulted in a cell density of 15.1 g/L with PHB content of 80.1% w/w and PHB concentration of 12.1 g/L, while 20% aeration gave a cell density of 11.3 g/L with 83.4% w/w PHB content and 9.4 g/L PHB concentration.

Reduced use of phosphorus and water in sequential dark fermentation and anaerobic digestion of wheat straw and the application of ensiled steam-pretreated lucerne as a macronutrient provider in anaerobic digestion.

BACKGROUND: Current EU directives demand increased use of renewable fuels in the transportation sector but restrict governmental support for production of biofuels produced from crops. The use of intercropped lucerne and wheat may comply with the directives. In the current study, the combination of ensiled lucerne (Medicago sativa L.) and wheat straw as substrate for hydrogen and methane production was investigated. Steam-pretreated and enzymatically hydrolysed wheat straw [WSH, 76% of total chemical oxygen demand (COD)] and ensiled lucerne (LH, 24% of total COD) were used for sequential hydrogen production through dark fermentation and methane production through anaerobic digestion and directly for anaerobic digestion. Synthetic co-cultures of extreme thermophilic Caldicellulosiruptor species adapted to elevated osmolalities were used for dark fermentation. RESULTS: Based on 6 tested steam pretreatment conditions, 5 min at 200 °C was chosen for the ensiled lucerne. The same conditions as applied for wheat straw (10 min at 200 °C with 1% acetic acid) would give similar sugar yields. Volumetric hydrogen productivities of 6.7 and 4.3 mmol/L/h and hydrogen yields of 1.9 and 1.8 mol/mol hexose were observed using WSH and the combination of WSH and LH, respectively, which were relatively low compared to those of the wild-type strains. The combinations of WSH plus LH and the effluent from dark fermentation of WSH plus LH were efficiently converted to methane in anaerobic digestion with COD removal of 85-89% at organic loading rates of COD 5.4 and 8.5 g/L/day, respectively, in UASB reactors. The nutrients in the combined hydrolysates could support this conversion. CONCLUSIONS: This study demonstrates the possibility of reducing the water addition to WSH by 26% and the phosphorus addition by 80% in dark fermentation with Caldicellulosiruptor species, compared to previous reports. WSH and combined WSH and LH were well tolerated by osmotolerant co-cultures. The yield was not significantly different when using defined media or hydrolysates with the same concentrations of sugars. However, the sugar concentration was negatively correlated with the hydrogen yield when comparing the results to previous reports. Hydrolysates and effluents from dark fermentation can be efficiently converted to methane. Lucerne can serve as macronutrient provider in anaerobic digestion. Intercropping with wheat is promising.

A non-linear model of hydrogen production by Caldicellulosiruptor saccharolyticus for diauxic-like consumption of lignocellulosic sugar mixtures.

BACKGROUND: Caldicellulosiruptor saccharolyticus is an attractive hydrogen producer suitable for growth on various lignocellulosic substrates. The aim of this study was to quantify uptake of pentose and hexose monosaccharides in an industrial substrate and to present a kinetic growth model of C. saccharolyticus that includes sugar uptake on defined and industrial media. The model is based on Monod and Hill kinetics extended with gas-to-liquid mass transfer and a cybernetic approach to describe diauxic-like growth. RESULTS: Mathematical expressions were developed to describe hydrogen production by C. saccharolyticus consuming glucose, xylose, and arabinose. The model parameters were calibrated against batch fermentation data. The experimental data included four different cases: glucose, xylose, sugar mixture, and wheat straw hydrolysate (WSH) fermentations. The fermentations were performed without yeast extract. The substrate uptake rate of C. saccharolyticus on single sugar-defined media was higher on glucose compared to xylose. In contrast, in the defined sugar mixture and WSH, the pentoses were consumed faster than glucose. Subsequently, the cultures entered a lag phase when all pentoses were consumed after which glucose uptake rate increased. This phenomenon suggested a diauxic-like behavior as was deduced from the successive appearance of two peaks in the hydrogen and carbon dioxide productivity. The observation could be described with a modified diauxic model including a second enzyme system with a higher affinity for glucose being expressed when pentose saccharides are consumed. This behavior was more pronounced when WSH was used as substrate. CONCLUSIONS: The previously observed co-consumption of glucose and pentoses with a preference for the latter was herein confirmed. However, once all pentoses were consumed, C. saccharolyticus most probably expressed another uptake system to account for the observed increased glucose uptake rate. This phenomenon could be quantitatively captured in a kinetic model of the entire diauxic-like growth process. Moreover, the observation indicates a regulation system that has fundamental research relevance, since pentose and glucose uptake in C. saccharolyticus has only been described with ABC transporters, whereas previously reported diauxic growth phenomena have been correlated mainly to PTS systems for sugar uptake.

Characterization of carotenoids in Rhodothermus marinus.

Rhodothermus marinus, a marine aerobic thermophile, was first isolated from an intertidal hot spring in Iceland. In recent years, the R. marinus strain PRI 493 has been genetically modified, which opens up possibilities for targeted metabolic engineering of the species, such as of the carotenoid biosynthetic pathway. In this study, the carotenoids of the R. marinus type-strain DSM 4252T , strain DSM 4253, and strain PRI 493 were characterized. Bioreactor cultivations were used for pressurized liquid extraction and analyzed by ultra-high performance supercritical fluid chromatography with diode array and quadropole time-of-flight mass spectrometry detection (UHPSFC-DAD-QTOF/MS). Salinixanthin, a carotenoid originally found in Salinibacter ruber and previously detected in strain DSM 4253, was identified in all three R. marinus strains, both in the hydroxylated and nonhydroxylated form. Furthermore, an additional and structurally distinct carotenoid was detected in the three strains. MS/MS fragmentation implied that the mass difference between salinixanthin and the novel carotenoid structure corresponded to the absence of a 4-keto group on the ß-ionone ring. The study confirmed the lack of carotenoids for the strain SB-71 (ΔtrpBΔpurAcrtBI'::trpB) in which genes encoding two enzymes of the proposed pathway are partially deleted. Moreover, antioxidant capacity was detected in extracts of all the examined R. marinus strains and found to be 2-4 times lower for the knock-out strain SB-71. A gene cluster with 11 genes in two operons in the R. marinusDSM 4252T genome was identified and analyzed, in which several genes were matched with carotenoid biosynthetic pathway genes in other organisms.

Close to the Edge: Growth Restrained by the NAD(P)H/ATP Formation Flux Ratio.

Most fermentative microorganisms grow well-under anaerobic conditions managing a balanced redox and appropriate energy metabolism, but a few species do exist in which cells have to cope with inadequate energy recovery or capture and/or redox balancing. Two cases of these species, i.e., the metabolically engineered Saccharomyces cerevisiae enabling it to ferment xylose and Lactobacillus reuteri fermenting glucose via the phosphoketolase pathway, are here used to introduce a quantification parameter to capture what limits the growth rate of these microorganisms under anaerobic conditions. This dimensionless parameter, the cofactor formation flux ratio (RJ ), is the ratio between the redox formation flux (JNADH+NADPH), and the energy carrier formation flux (JATP), which are mainly connected to the central carbon pathways. Data from metabolic flux analyses performed in previous and present studies were used to estimate the RJ -values. Even though both microorganisms possess different central pathways, a similar relationship between RJ and the specific growth rate (µ) was found. Furthermore, for both microorganisms external electron acceptors moderately reduced the RJ -value, thereby raising the µ accordingly. Based on the emerging profile of this relationship an interpretation is presented suggesting that this quantitative analysis can be applied beyond the two microbial species experimentally investigated in the current study to provide data for future targeted strain development strategies.

Adaptation to low pH and lignocellulosic inhibitors resulting in ethanolic fermentation and growth of Saccharomyces cerevisiae.

Lignocellulosic bioethanol from renewable feedstocks using Saccharomyces cerevisiae is a promising alternative to fossil fuels owing to environmental challenges. S. cerevisiae is frequently challenged by bacterial contamination and a combination of lignocellulosic inhibitors formed during the pre-treatment, in terms of growth, ethanol yield and productivity. We investigated the phenotypic robustness of a brewing yeast strain TMB3500 and its ability to adapt to low pH thereby preventing bacterial contamination along with lignocellulosic inhibitors by short-term adaptation and adaptive lab evolution (ALE). The short-term adaptation strategy was used to investigate the inherent ability of strain TMB3500 to activate a robust phenotype involving pre-culturing yeast cells in defined medium with lignocellulosic inhibitors at pH 5.0 until late exponential phase prior to inoculating them in defined media with the same inhibitor cocktail at pH 3.7. Adapted cells were able to grow aerobically, ferment anaerobically (glucose exhaustion by 19 ± 5 h to yield 0.45 ± 0.01 g ethanol g glucose(-1)) and portray significant detoxification of inhibitors at pH 3.7, when compared to non-adapted cells. ALE was performed to investigate whether a stable strain could be developed to grow and ferment at low pH with lignocellulosic inhibitors in a continuous suspension culture. Though a robust population was obtained after 3600 h with an ability to grow and ferment at pH 3.7 with inhibitors, inhibitor robustness was not stable as indicated by the characterisation of the evolved culture possibly due to phenotypic plasticity. With further research, this short-term adaptation and low pH strategy could be successfully applied in lignocellulosic ethanol plants to prevent bacterial contamination.

Biological Processes for Hydrogen Production.

Methane is produced usually from organic waste in a straightforward anaerobic digestion process. However, hydrogen production is technically more challenging as more stages are needed to convert all biomass to hydrogen because of thermodynamic constraints. Nevertheless, the benefit of hydrogen is that it can be produced, both biologically and thermochemically, in more than one way from either organic compounds or water. Research in biological hydrogen production is booming, as reflected by the myriad of recently published reviews on the topic. This overview is written from the perspective of how to transfer as much energy as possible from the feedstock into the gaseous products hydrogen, and to a lesser extent, methane. The status and remaining challenges of all the biological processes are concisely discussed.

Evaluation of assimilatory sulphur metabolism in Caldicellulosiruptor saccharolyticus.

Caldicellulosiruptor saccharolyticus has gained reputation as being among the best microorganisms to produce H2 due to possession of various appropriate features. The quest to develop an inexpensive cultivation medium led to determine a possible replacement of the expensive component cysteine, i.e. sulphate. C. saccharolyticus assimilated sulphate successfully in absence of a reducing agent without releasing hydrogen sulphide. A complete set of genes coding for enzymes required for sulphate assimilation were found in the majority of Caldicellulosiruptor species including C. saccharolyticus. C. saccharolyticus displayed indifferent physiological behaviour to source of sulphur when grown under favourable conditions in continuous cultures. Increasing the usual concentration of sulphur in the feed medium increased substrate conversion. Choice of sulphur source did not affect the tolerance of C. saccharolyticus to high partial pressures of H2. Thus, sulphate can be a principle sulphur source in an economically viable and more sustainable biohydrogen process using C. saccharolyticus.

Assessment of metabolic flux distribution in the thermophilic hydrogen producer Caloramator celer as affected by external pH and hydrogen partial pressure.

BACKGROUND: Caloramator celer is a strict anaerobic, alkalitolerant, thermophilic bacterium capable of converting glucose to hydrogen (H2), carbon dioxide, acetate, ethanol and formate by a mixed acid fermentation. Depending on the growth conditions C. celer can produce H2 at high yields. For a biotechnological exploitation of this bacterium for H2 production it is crucial to understand the factors that regulate carbon and electron fluxes and therefore the final distribution of metabolites to channel the metabolic flux towards the desired product. RESULTS: Combining experimental results from batch fermentations with genome analysis, reconstruction of central carbon metabolism and metabolic flux analysis (MFA), this study shed light on glucose catabolism of the thermophilic alkalitolerant bacterium C. celer. Two innate factors pertaining to culture conditions have been identified to significantly affect the metabolic flux distribution: culture pH and partial pressures of H2 (PH2). Overall, at alkaline to neutral pH the rate of biomass synthesis was maximized, whereas at acidic pH the lower growth rate and the less efficient biomass formation are accompanied with more efficient energy recovery from the substrate indicating high cell maintenance possibly to sustain intracellular pH homeostasis. Higher H2 yields were associated with fermentation at acidic pH as a consequence of the lower synthesis of other reduced by-products such as formate and ethanol. In contrast, PH2 did not affect the growth of C. celer on glucose. At high PH2 the cellular redox state was balanced by rerouting the flow of carbon and electrons to ethanol and formate production allowing unaltered glycolytic flux and growth rate, but resulting in a decreased H2 synthesis. CONCLUSION: C. celer possesses a flexible fermentative metabolism that allows redistribution of fluxes at key metabolic nodes to simultaneously control redox state and efficiently harvest energy from substrate even under unfavorable conditions (i.e. low pH and high PH2). With the H2 production in mind, acidic pH and low PH2 should be preferred for a high yield-oriented process, while a high productivity-oriented process can be achieved at alkaline pH and high PH2.

Physiological effects of over-expressing compartment-specific components of the protein folding machinery in xylose-fermenting Saccharomyces cerevisiae.

BACKGROUND: Efficient utilization of both glucose and xylose is necessary for a competitive ethanol production from lignocellulosic materials. Although many advances have been made in the development of xylose-fermenting strains of Saccharomyces cerevisiae, the productivity remains much lower compared to glucose. Previous transcriptional analyses of recombinant xylose-fermenting strains have mainly focused on central carbon metabolism. Very little attention has been given to other fundamental cellular processes such as the folding of proteins. Analysis of previously measured transcript levels in a recombinant XR/XDH-strain showed a wide down-regulation of genes targeted by the unfolded protein response during xylose fermentation. Under anaerobic conditions the folding of proteins is directly connected with fumarate metabolism and requires two essential enzymes: FADH2-dependent fumarate reductase (FR) and Ero1p. In this study we tested whether these enzymes impair the protein folding process causing the very slow growth of recombinant yeast strains on xylose under anaerobic conditions. RESULTS: Four strains over-expressing the cytosolic (FRD1) or mitochondrial (OSM1) FR genes and ERO1 in different combinations were constructed. The growth and fermentation performance was evaluated in defined medium as well as in a complex medium containing glucose and xylose. Over-expression of FRD1, alone or in combination with ERO1, did not have any significant effect on xylose fermentation in any medium used. Over-expression of OSM1, on the other hand, led to a diversion of carbon from glycerol to acetate and a decrease in growth rate by 39% in defined medium and by 25% in complex medium. Combined over-expression of OSM1 and ERO1 led to the same diversion of carbon from glycerol to acetate and had a stronger detrimental effect on the growth in complex medium. CONCLUSIONS: Increasing the activities of the FR enzymes and Ero1p is not sufficient to increase the anaerobic growth on xylose. So additional components of the protein folding mechanism that were identified in transcription analysis of UPR related genes may also be limiting. This includes i) the transcription factor encoded by HAC1 ii) the activity of Pdi1p and iii) the requirement of free FAD during anaerobic growth.